Product ID:N1207 A EARTH YELLOW CAMO TYPE IV
MSDS Date:10/11/1989
FSC:8010
NIIN:01-141-2415
Kit Part:Y
MSDS Number: BHNFF

NILES CHEMICAL PAINT COMPANY

225 FORT STREET
NILES, MI 49120
US

Emergency Phone: 219-236-5856 (24 HOURS)

Info Phone: 616-683-3377 (INFORMATION)

Preparer: MIKE LICHATOWICH

Cage: 02388

NILES CHEMICAL PAINT

307 NILES, MI 49120 US

Telephone: 616-683-3377/219-236-5856

Cage: 02388

PROPYLENE GLYCOL METHYL ETHER ACETATE

CAS: 108-65-6

RTECS: AF8925000

Fraction By Weight: 17%

OSHA PEL NONE ESTABLISHED

ACGIH TLV: NONE ESTABLISHED

POLYESTER RESIN

Fraction By Weight: 16%

N-BUTYL ACETATE (SARA III)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 9%

OSHA PEL 150 PPM/200 STEL

ACGIH TLV: 150 PPM/200STEL;9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 7%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 3%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CHROMIUM (III) OXIDE

CAS: 1308-38-9

RTECS: GB6475000

Fraction By Weight: 1%

OSHA PEL 0.5 MG/M3 (CR)

ACGIH TLV: 0.5 MG/M3 (CR); 8990

VOC. ORGANIC CMPD 4.3 LB/GAL

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:HISTOLOGIC FIBROSIS OF LUNGS,
INCOHERENCE, CORNEAL VACUOLIZATION, ANOREXIA. TARGET ORGANS:
CNS, LUNGS, EYES, SKIN, RESPIRATORY SYSTEM, GI TRACT, BLOOD,
LIVER, & KIDNEYS
Effects of Overexposure:EYES: SEVERE IRRITATION, LACRIMATION, REDNESS,
BLURRED VISION. SKIN: REDNESS & IRRITATION,
DEFATTING OF SKIN LEADING TO DERMATITIS. INHAL:
NASAL/RESP. IRRIT., CNS DEPRSN.,N
AUSEA,HDACHE,VERTIGO,UNCONSC.,ASPHYXATN.INGST: ABDOMINAL
PAIN,NAUSEA,VOMITING,DIARRHEA,GASTROINTESTINAL IRRITATION
Medical Cond Aggravated by Exposure:NONE

First Aid:EYE: IMMD. FLUSH WITH LRG AMTS OF WTR FOR 15 MINS.,LIFTING
EYELIDS,GET MED ATTN.SKIN: IMMD. FLUSH W/PLNTY OF WTR, IMMD. REMOVE
CLOTHING W/WTR, GET MED. ATTN. INHALE: REMOVE TO FRESH AIR, GIVE
ARTIFI CIAL RESP. GET MEDICAL ATTENTION IMMED.INGESTION: DO NOT
INDUCE VOMITING, DRINK 1-2 GLASSES OF WATER. CONSULT A
PHYSICIAN IMMEDIATELY.

Flash Point Method:TCC
Flash Point:20F/-6C
Lower Limits:1.0
Upper Limits:10
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SCBA W/FACEPIECE W/POSITIVE PRESS MODE &
FULL PROTECTIVE CLTHNG. WTR MAYBE USED TO COOL CLSD CONTNR TO
PREVNT PRESS BUILDUP & POSS. IGN./EXPLSN TO EXTM HT.
Unusual Fire/Explosion Hazard:KEEP CONTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT,SPARKS,ELEC EQUIP,& OPEN FLAME. CLOSED CONTNR MAY EXPLD
W/EXPSD TO EXTRM HT. VAPORS >AIR & MAY TRVL GRND IGN SOURCE

Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. DIKE TO
PREVENTFURTHER MOVEMENT & RECLAIM INTO RECOVERY OR SALV- AGE DRUMS
OR TANK TRUCK FOR DISPOSAL. ABSORB WITH INERT MATL SUCH AS CLAY,
SOIL, OR A COMMERCIALLY AVAILABLE ABSORBENT. AVOID SKIN CONTACT&
VAPORS.

Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE, OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. AVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF THE MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD/FLAME CUT ONEMPTY DRUMS. CONTACT LENS SHOULD NOT
BE WORN WHILE WORKING WITH THIS MATERIAL.

Respiratory Protection:WEAR AN APPROPRIATE PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA) DURING AND AFTER APPLICATION UNLESS AIR MONITORING
DEMONSTRATES VAPOR AND/OR MIST LVLS ARE BELOW APPLICABLE LIMITS.
Ventilation:SUFFICIENT VENTILATION IN VOLUME/PATTERN TO KEEP AIR
CONCEN-TRATIONS BELOW PERMISSIBLE EXPOSURE LIMITS OR TLV LIMITS.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:CHEMICAL GOGGLES/GLASSES/& FACESHIELD
Other Protective Equipment:CLOTHING AS NEEDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
RESTROOM. WASH CONTAMINATED CLOTHING & DECONTAMINATE SHOES BEFORE
RE-USE.
Supplemental Safety and Health
KEY1:F3. KIT CONSISTS OF TWO PARTS. PART ONE HAS PNI A, PART TWO HAS
PNI B, SAME NSN.

HCC:F2
Boiling Pt:B.P. Text:***
Vapor Density:> AIR
Viscosity:70-85 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:57.72

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, NITRATES, ALKALIES, ACIDS.
Stability Condition to Avoid:HIGH TEMPERATURES, SHOCK FROM DROPPING.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:***BOIL PT: 175-302F/70-150C.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS. SHOVEL RECLAIMED
LIQUID & ABSORBENT INTO RECOVERY OR SALVAGE DRUMS FOR DISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.